How much does it cost to replace the PTU on a Ford Edge?

How much does it cost to replace the PTU on a Ford Edge?

$1830 to replace. Had the PTU replaced at around 120K after a 2month wait for the part. It cost about 1,800.00!!

What are PTU seals?

The PTU is an all-wheel drive (AWD) transfer case used in cars and sport utility vehicles. It allows for power to all four wheels either part time or full time, and also varies how much power goes to the front and rear by specific driving conditions.

What happens when PTU fails?

Symptoms of a failing or failed PTU include hearing a grinding, growling, or humming noise that changes with your vehicle’s speed, which can be the result of low fluid from a leak and/or bad bearings, loose chains and damaged gears. If the PTU has gone bad then you will unlikely be able to drive the vehicle.

Does a 2007 Ford Edge have a transfer case?

This transfer case will fit a 2007 Ford Edge AWD (ALL WHEEL DRIVE). You can expect to receive your transfer case within 2-5 business days. We highly recommend you replace the transfer case fluid prior to installation. We typically drain the transfer case of it’s fluid before shipping it.

How do I know if my PTU is bad?

When it leaks you can get a terrible burning oil smell if it drips on the exhaust as well as possible “black” oil drops on the ground under the unit. A bad ptu often starts to bind and make grinding noise when it is damaged and really on its way out. Fluid changes can greatly improve the longevity of the ptu.

Is there a recall on Ford Edge?

Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.

Is the PTU part of the transmission?

The “transfer case” that is used in FWD vehicles is called a power transfer unit (PTU), which is attached to the transaxle and sends power to a rear differential.

Is PTU covered under powertrain warranty?

The PTU is covered by the 3yr/36,000 mile factory warranty and the 5yr/60,000 mile powertrain warranty.

How do I know if my Ford PTU is bad?

Does the Ford Edge have a transfer case?

Problems: Power transfer unit (PTU) failures and leaks have been reported by many owners. The PTU is a compact transfer case in the AWD system. It’s attached to the transmission and has a few gears inside to angle the rotating torque towards the rear differential. 2011 Ford Edge.

How much does it cost to replace a PTU on a Ford Explorer?

The PTU is usually available off eBay from a Ford dealer for $800 or so shipped. So typical non-dealer costs will range from $1,200 (including PTU) to $1,500 depending on rates in Your area.